August 1, 1998
By Bruce Landsberg
Everyone knows that thunderstorms need to be avoided. Yet, to fly in the season we must operate with them around. But even for seasoned pilots Thor may have a few surprises — something that didn't appear in the rulebooks or a situation that looked so similar to previous circumstances that pilots were tempted to try a strategy that always worked before. Here are two accidents in which both aircraft had their windshields broken, with subsequent forced landings. Neither pilot anticipated the hazards that the particular storms held. There is a message here for all pilots, not just those who fly heavy iron.
April 4, 1977, was a typical spring day. A strong cold front extended from a low-pressure system near the Great Lakes and was forecast to move across Arkansas, Louisiana, and Kentucky. The area forecast, issued by the National Weather Service (NWS), called for marginal VFR conditions, visibilities 3 to 5 miles in haze, and 1,000- to 2,000-foot overcasts, with occasional IFR conditions. There were conditions. There were layered clouds up to 19,000 feet. Scattered thunderstorms with tops to 35,000 feet were forecast. A few severe storms were predicted near the front, with tops to 55,000 feet.
A Southern Airways DC-9 departed Atlanta around 2 p.m. EST for a short flight over to Muscle Shoals, Alabama. As Flight 242, it departed Muscle Shoals with the same Atlanta crew at 3:21 and landed at Huntsville, Alabama, at 3:44. During the turnaround in Muscle Shoals the crew received tornado watches that covered much of the Southeast and several sigmets pertaining to embedded thunderstorms that were forecast for the flight's operating area. At 3:20 Sigmet Charlie 7 called for scattered to numerous thunderstorms to develop, occasionally in lines — a few severe, with possible tornadoes.
The crew did not leave the cockpit at Huntsville, and the first officer was elected to fly the leg back to Atlanta. Southern's dispatchers provided terminal sequence reports (METARs in today's vocabulary) that showed cloudy, warm, and windy conditions at Atlanta's Hartsfield Airport with 2,700 feet broken, 5,000 broken, and 25,000 overcast. The visibility was 5 miles with the wind out of the southwest at 31, gusting to 47 mph. No mention was made of the squall line that had developed and was showing up on the National Weather Service radar at Athens, Georgia, at 3:34. Four-tenths of the area was covered, and the echoes were moving east-northeast at 55 knots. The maximum precipitation return was near Rome, Georgia, with tops to 46,000 feet. The crew had flown through this area two hours earlier with nothing more than some rain and light turbulence.
At 3:54 Flight 242 departed Huntsville for the return trip to Atlanta with a clearance to 17,000 feet. The flight was cleared direct to Rome, and the cockpit conversation turned to weather. The captain remarked, "Well, the radar is full of it; take your pick." At 3:56 the controller told Flight 242 that his radar scope was showing heavy precipitation and that the echoes were about five miles ahead of the flight. The crew asked if it looked worse than what they were in, and the controller responded that he had weather attenuation devices on and that it might be heavier. The crew acknowledged, and the flight was handed off to Memphis Center.
At 3:58 the captain said, "If it doesn't get any heavier than this, we'll be all right." And the FO replied, "Yeah, this is good." Memphis Center then advised the flight that a sigmet had been issued for the area; it advised them to monitor VOR broadcasts and to contact Atlanta Center. At 3:59 the captain said, "Here we go...hold 'em, cowboy." It was a prophetic statement.
The flight checked in with Atlanta Center, and the captain suggested that the FO reduce the aircraft speed for turbulence. Between 3:59 and 4:02 Center discussed the weather with other air carrier flights in the area. TWA was asking for deviations, and the controller wanted to know how Eastern's ride was through the line. Eastern's response was, "It was not too comfortable, but we didn't get into anything we would consider the least bit hazardous."
In the following transcript of communications during this scenario, conversations conducted inside the cockpit are italicized; those between the aircraft and the ground are not. Capt is Flight 242's captain, FO is the first officer, S242 is radio transmissions from the flight, AC is Atlanta Center, AA is Atlanta Approach, and CAM denotes information from the airplane's cockpit area mic. Dialog in italics is crew conversation recorded on the DC-9's cockpit voice recorder.
4:03:48 Capt: "Looks heavy, nothing's going through that." 4:03:54 Capt: "See that?" 4:03:56 FO: "That's a hole, isn't it?" 4:03:57 Capt: "It's not showing a hole; see it?" 4:04:05 CAM: (Sound of rain) 4:04:08 FO: "Do you want to go around that right now?" 4:04:19 Capt: "Hand fly at about two eighty-five knots." FO: "Two eight five." 4:04:30 CAM: (Sound of hail and rain) 4:04:53 S242: "Southern Two-Forty-Two, we're slowing it up here a little bit." 4:04:53 AC: "Two-Forty-Two, roger." 4:05:53 FO: "Which way do we go, cross here or go out — I don't know how we get through there, Bill." Capt: "I know you're just gonna have to go out...." FO: "Yeah, right across that band." 4:06:01 Capt: "All clear left approximately right now; I think we can cut across there now." 4:06:12 FO: "All right, here we go." 4:06:25 FO: "We're picking up some ice, Bill." 4:06:29 Capt: "We are above 10 degrees." FO: "Right at 10." Capt: "Yeah." 4:06:30 AC (to TWA 584): "I show the weather up northwest of that position north of Rome, just on the edge of it — I tell you what, maintain one five thousand." 4:06:38 TWA 584: "Maintain one five thousand; we paint pretty good weather one or two o'clock." 4:06:41 FO: "He's got to be right through that hole about now." 4:06:42 AC: "Southern Two-Forty-Two descend and maintain one four thousand at this time." 4:06:46 Capt: "Who's that?" 4:06:48 FO: "TWA." AC: "Southern Two-Forty-Two, descend and maintain one four thousand." 4:06:53 S242: "Two-Forty-Two down to fourteen." 4:06:55 AC: "Affirmative." CAM: (Heavy hail or rain sound starts and continues until power interruption.) 4:07:00 AC: "Southern Two-Forty-Two, Atlanta altimeter two-niner-five-six, and cross 40 miles northwest of Atlanta two-five-zero knots." CAM: (Sound similar to electrical disturbance) 4:07:57 CAM: (Power interruption for 36 seconds) 4:08:33 CAM: (Power restored) CAM: (Sound of rain continues for 40 seconds) 4:08:34 AC: "Southern Two-Forty-Two, Atlanta." 4:08:37 FO: "Got it, got it back, Bill; got it back, got it back [probably referring to the engines]." 4:08:42 S242: "Uh, Two-Forty-Two, stand by." 4:08:46 AC: "Say again." 4:08:48 S242: "Stand by." 4:08:49 AC: "Roger, maintain one five thousand if you understand me; maintain one five thousand, Southern Two-Forty-Two." 4:08:55 S242: "We're trying to get it up there." 4:08:57 AC: "Roger." 4:09:15 S242: "Okay, uh, Two-Forty-Two, uh, we just got our windshield busted and, uh, we'll try to get it back up to fifteen, we're fourteen." 4:09:24 FO: "Fifteen thousand." 4:09:25 AC: "Southern Two-Forty-Two, you say you're at fourteen now?" 4:09:27 S242: "Yeah, uh, couldn't help it." 4:09:30 AC: "That's OK, uh, are you squawking five-six-two-three?" 4:09:36 FO: "Left engine won't spool." 4:09:37 S242: "Our left engine just cut out." 4:09:42 AC: "Southern Two-Forty-Two roger, and, uh, lost your transponder, squawk five-six-two-three." 4:09:43 FO: "I am squawking five-six-two-three, tell him I'm level fourteen." 4:09:49 S242: "Five-six-two-three, we're squawking." 4:09:53 AC: "Say you lost an engine and, uh, busted a windshield?" 4:09:56 S242: "Yes sir." 4:09:59 Capt: "Autopilot's off." FO: "I've got it; I'll hand-fly it." 4:10:00 AC: "Southern Two-Forty-Two, you can descend and maintain one three thousand now, that'll get you down a little lower." 4:10:04 FO: "My (deleted), the other engine's going, too (deleted)" 4:10:05 S242: "Got the other engine going, too." 4:10:08 AC: "Southern Two-Forty-Two, say again." 4:10:10 S242: "Stand by — we lost both engines." 4:10:14 FO: "All right, Bill, get us a vector to a clear area." 4:10:16 S242: "Get us a vector to a clear area, Atlanta." 4:10:20 AC: "Uh, continue present southeastern bound heading; TWA's off to your left about 14 miles at fourteen thousand and says he's in the clear." 4:10:25 S242: "OK." 4:10:27 S242: "Want us to turn left?" 4:10:30 AC: "Southern Two-Forty-Two, contact approach control, one two six point nine, and they'll try to get you straight into Dobbins." 4:10:35 S242: "One two —." 4:10:36 FO: "Give me — I'm familiar with Dobbins; tell them to give me a vector to Dobbins if they're clear. 4:10:38 S242: "Give me, uh, vector to Dobbins if they're clear." 4:10:41 AC: "Southern Two-Forty-Two, one twenty-six point nine, they'll give you a vector to Dobbins." 4:10:45 S242: "Twenty-six nine, OK." 4:10:50 FO: "Ignition override, it's gotta work by (deleted)." 4:10:56 CAM: [Power interruption for 2 minutes, 4 seconds] 4:13:00 CAM: [Power restored] 4:13:03 Capt: "There we go." FO: "Get us a vector to Dobbins." 4:13:04 S242: "Uh, Atlanta, you read Southern Two-Forty-Two?" 4:13:08 AA: "Southern Two-Forty-Two, Atlanta approach control; uh, go ahead. 4:13:11 S242: "Uh, we've lost both engines — how about giving us a vector to the nearest place. We're at seven thousand feet. 4:13:17 AA: "Southern Two-Forty-Two, roger, turn right heading one zero zero, will be vectors to Dobbins for a straight-in approach Runway One-One, altimeter two niner five two, your position is 15, correction 20 miles west of Dobbins at this time." 4:13:18 FO: "What's Dobbins' weather, Bill? How far is it? How far is it?" 4:13:31 S242: "Okay, uh, one-forty heading and 20 miles." 4:13:35 AA: "Ah, make a heading of one-two-zero, Southern Two-Forty-Two, right turn to one-two-zero." 4:13:40 S242: "Okay, right turn to one-two-zero and, uh, you got us our squawk, haven't you, on emergency?" FO: "Declare an emergency, Bill." 4:13:45 AA: "Uh, I'm not receiving it. But radar contact; your position is 20 miles west of Dobbins." 4:14:03 FO: "Get those engines (deleted)." 4:14:24 S242: "All right, listen, we've lost both engines, and, uh, I can't, uh, tell you the implications of this — we, uh, only got two engines and how far is Dobbins now?" 4:14:34 AA: "Southern, uh, Two-Forty-Two, uh, 19 miles." 4:14:40 S242: "OK, we're out of, uh, fifty-eight hundred, 200 knots." 4:14:44 FO: "What's our speed? Let's see, what's our weight, Bill? Get me a bug speed." 4:14:45 AA: "Southern Two-Forty-Two, do you have one engine running now?" 4:14:47 FO: "No." 4:14:48 S242: "Negative, no engines." 4:14:50 AA: "Roger." 4:14:59 Capt: "One twenty six." [This probably refers to the final approach speed.] FO: "One twenty six." 4:15:04 Capt: "Just don't stall this thing out." FO: "No, I won't." Capt: "Get your wing flaps." CAM: [Sound of lever movement.] 4:15:11 FO: "Got it, got hydraulics so we got...." Capt: "We got hydraulics." 4:15:17 FO: "What's the Dobbins weather? 4:15:18 S242: "What's your Dobbins weather?" 4:15:22 AA: "Stand by." 4:15:25 FO: "Get Dobbins on the approach plate." 4:15:42 Capt: "I can't find Dobbins. Tell me where's it at? Atlanta?" FO: "Yes." 4:15:46 AA: "Southern Two-Forty-Two, Dobbins weather is two thousand scattered, estimated ceiling three thousand broken, seven thousand overcast, visibility seven miles." 4:15:57 S242: "OK, we're down to forty-six hundred now." 4:15:59 FO: "How far is it? How far is it?" 4:16:00 AA: "Roger, and you're approximately, uh, 17 miles west of Dobbins at this time." 4:16:05 S242: "I don't know whether we can make that or not." 4:16:07 AA: "Roger." 4:16:11 FO: "Ah, ask him if there is anything between here and Dobbins? Capt: "What?" FO: "Ask him if there is anything between here and Dobbins." 4:16:25 S242: "Uh, is there any airport between our position and Dobbins?" 4:16:29 AA: "Southern Two-Forty-Two, uh, no sir, uh, closest airport is Dobbins." 4:16:34 S242: "I doubt we're going to make it, but we're trying everything to get something started." 4:16:38 AA: "Roger, well, there is Cartersville; you're approximately 10 miles south of Cartersville, 15 miles west of Dobbins." 4:16:44 FO: "We'll take a vector to that. Yes, we'll have to go there." 4:16:45 S242: "Can you give us a vector to Cartersville?" 4:16:47 AA: "All right, turn left, heading of three-six-zero be directly, uh, direct vector to Cartersville." 4:16:52 S242: "Three six zero, roger." FO: "What runway? What's the heading on the runway?" 4:16:53 S242: "What's the runway heading?" 4:16:58 AA: "Stand by." 4:16:59 S242: "And how long is it?" 4:17:00 AA: "Stand by." 4:17:08 Capt: "Like we are, I'm picking out a clear field." 4:17:12 FO: "Bill, you've got to find me a highway." Capt: "Let's get the next clear open field." FO: "No (deleted)." 4:17:35 Capt: "See a highway over — no cars." FO: "Right there, is that straight?" 4:17:39 Capt: "No." 4:17:44 AA: "Southern Two-Forty-Two, the runway configuration..." FO: "We'll have to take it." 4:17:55 AA: "...at Cartersville is, uh, three six zero and running north and south and the elevation is seven hundred fifty-six feet and, uh, trying to get the length of now — it's three thousand two hundred feet long." 4:17:58 CAM: [Beep on gear horn.] CAM: [Gear horn steady for 4 seconds.] 4:18:02 S242: "Uh, we're putting it on the highway, we're down to nothing." 4 :18:07 FO: "Flaps." Capt: "They're at fifty." FO: "Oh (deleted), Bill, I hope we can do it." 4:18:14 FO: "I've got it, I got it." 4:18:15 FO: "I'm going to land right over that guy." 4:18:20 Capt: "There's a car ahead." 4:18:25 FO: "I got it Bill, I've got it now, I got it. Capt: "OK." 4:18:30 Capt: "Don't stall it." FO: "I gotta bug." 4:18:31 FO: "We're going to do it right here." 4:18:34 FO: "I got it." 4:18:36 CAM: [Sound of breakup.] 4:18:43 End of tape.
Flight 242 crashed on a road and slid for roughly 1,830 feet before colliding with a convenience store/gas station. Sixty-two people on board the aircraft died, including the cockpit crew. Eight people on the ground also perished. There were 21 passengers who survived, along with the flight attendants.
According to one of the surviving passengers who held a commercial pilot certificate, the flight was routine until the aircraft encountered severe turbulence, followed by very heavy precipitation, a lightning strike on the left wing tip, and hail. The hail increased in size and intensity, then the right engine quit, and the left engine quit shortly thereafter. Coincident with the turbulence, the power was reduced on the engines. The passenger estimated that the turbulence lasted one to two minutes, the heavy rain continued for 45 seconds, and the hail for about the same amount of time. The engines quit just after the hail stopped. Shortly after that the auxiliary power unit (APU) was started. The two flight attendants had similar recollections.
According to the post-accident analysis by the NWS, the storm system was one of the worst on record, spawning 20 tornadoes and 30 severe thunderstorms. It was clearly not business as usual. According to the radar plot, Flight 242 went through the line very close to the largest thunderstorm cell. Level Five is categorized as an intense thunderstorm with rainfall rate of 2 to 5 inches per hour, and Level Six is considered extreme.
Never before had an air carrier aircraft had both engines snuffed out by a thunderstorm. The probability was considered so remote that the aircraft flight manual had no guidance on what to do when a DC-9 becomes a glider. The maximum gliding distance from 14,000 feet was estimated at 34 miles. The crew coaxed about 32.5 miles out of the aircraft, which is a remarkable performance for an untrained maneuver.
In a masterful understatement the NTSB concluded that "after complete failure of the engines, an accident was most probably inevitable...." The board surmised that shortly after the loss of the engines, the flight may have entered visual conditions. The pilots, busy with attempted restart of both engines and the APU to restore electrical power, chose to stay visual, which may account for the 180-degree turn westbound.
The findings were that the flight penetrated a severe thunderstorm and the ingestion of intense rain and hail caused both engines to fail. The engines suffered internal damage and could not be restarted. The crew had no information on the storms west of Rome, and the captain initially decided, based on his airborne weather radar returns, that the storms were too severe to penetrate. For some reason or because of misinterpretation of the radar display, he changed his mind.
The Board determined the probable cause to be the "total and unique loss of thrust from both engines while the aircraft was penetrating an area of severe weather." Board member Francis McAdams dissented, stating that the majority belief "was merely a statement of what happened rather than an explanation of why." His determination of probable cause is more likely much closer to the mark. "This accident involves the captain's critical decision to penetrate rather than avoid a known area of severe weather.... It is obvious that the captain flew a route or directed the FO to fly a route into an area which aircraft should not have entered. Southern Airways, and all air carriers, prohibit flying into convective storms because these types of storms are known to be serious hazards. The primary hazard relates to forces in these storms which can destroy an aircraft structurally; however, other hazards exist which are not well defined.... The loss of thrust...might have been unusual...but should not be considered entirely unexpected, given the multiple hazards associated with flight into severe convective storms."
With this well-researched accident in mind, let's review how the pilot in a GA aircraft also misread the power of the force. On August 30, 1996, a Cessna 421B with a 3,000-hour instrument-rated private pilot started a trip from New Mexico to Oklahoma. At 4:15 p.m. the pilot called flight service to get a briefing and file an IFR flight plan. He was advised of building thunderstorm activity from Raton, New Mexico, to Garden City, Kansas. There were scattered thunderstorms in the Oklahoma panhandle, but there were no sigmets.
The flight departed and checked in with Albuquerque Center. It was cleared to Flight Level 210, and shortly afterward the pilot asked for FL190. That was approved with no unusual communications or comments regarding the weather. At 6:23 p.m. Albuquerque lost radar contact with the 421. At 5:55 a convective sigmet was issued for isolated severe storms with 20-mile diameters and tops to 45,000 feet, but this information was never passed to the pilot.
In his written report of the accident, the pilot stated that there were "some clouds" approximately 50 to 60 miles ahead. "I turned on the on-board radar scope and could see precipitation to the left and right of our path. However, the center area, probably 15 to 20 miles wide, was clear on the scope. This was the area that I planned to go through the clouds. They did not appear to be dark thunderstorms, only clouds like I had flown through many times before.
"Before we reached those clouds, about 10 miles before, is when we encountered hail. It first appeared as rain, and then within one minute of the first encounter, a large piece of ice broke through the left windshield."
The right-seat passenger was a private pilot who was neither instrument- nor multiengine-rated. He noted that the on-board weather radar was on but did not indicate strong storms directly in their path. "It showed rain on both sides but just a small ring of rain in front." After the windshield broke, the left-seat pilot appeared dazed and put his head in his lap. The passenger took over the controls and attempted to keep the wings level. He stated that he "never felt dizzy or lightheaded."
The next thing the right-seat passenger remembered was the back-seat passenger waking him up on the ground. The 421 had crashed in an open field and all the occupants survived. A call to 911 on a cellular telephone brought help about four hours later because of the remoteness of the site.
Both of these accidents remind us that one of the primary tools that we have in order to avoid thunderstorms — weather radar — is fallible. Or perhaps it would be more correct to say that interpretation must be done carefully. Situations that look flyable, based on prior experience, may not be. The Southern Airways captain failed to reckon with the explosive growth of what had been a benign line of weather two hours earlier and didn't take full advantage of the resources available to him. The Cessna 421 pilot took what appeared to be a reasonable course of action. He learned about radar attenuation and that hail does not show up well on radar. Mountain-state storms frequently have hail and require a wide berth.
In discussion of these accidents with some very experienced pilots, they all had the same admonishment — thunderstorms, by nature, are unpredictable and a healthy distance is good insurance. Some of the very best flying hours are those spent avoiding convective activity.
On May 7, 1998, a DC-9 en route from Atlanta to Chicago encountered turbulence and hail while climbing through 20,000 feet. The aircraft was in instrument conditions and received substantial damage. A flight attendant was seriously injured. The flight crew was deviating around weather and was following another aircraft that went through the same area between two cells.
The hail lasted about five seconds, with moderate turbulence for 30 seconds. Three front windshield outer panels were shattered, with impact damage to the wing leading edge, horizontal stabilizer, and engine inlet cowls. Both engines were also damaged as the aircraft radome separated from the aircraft and was partially ingested by the engines. Both airspeed indicators also became inoperative; ATC provided speed readouts every 10 to 15 seconds. The flight made an emergency landing in Chattanooga, Tennessee. A major investigation is in progress.
See also the index of "Safety Pilot" articles, organized by subject. Bruce Landsberg is executive director of the AOPA Air Safety Foundation.
Safety and Education,
Pilot Training and Certification
Aerospace and defense giant Lockheed Martin stirred the pot with an Oct. 15 announcement that compact fusion could power vehicles, even aircraft, within a decade. Skeptics were quick to speak up, while Lockheed filed for patents and hopes to find partners in government, academia, and industry.
On Oct. 18, STEM education moved from classrooms to cockpits in Lansing, Michigan, and made a lasting impression.
Elbit Systems has upgraded infrared systems that see through darkness and weather for nearly visual landings and takeoffs, as well as taxi operations.
VOLUNTEER AT AN AOPA FLY-IN NEAR YOU!
SHARE YOUR PASSION. VOLUNTEER AT AN AOPA FLY-IN. CLICK TO LEARN MORE >>>
VOLUNTEER LOCALLY AT AOPA FLY-IN! CLICK TO LEARN MORE >>>
BE A PART OF THE FLY-IN VOLUNTEER CREW! CLICK TO LEARN MORE >>>