August 25, 2014
By Jim Moore
The FAA cited a smoke condition that preceded a fatal accident as the basis for its decision to update an airworthiness directive requiring inspection of Meggitt (Troy) combustion heaters previously sold under the Stewart Warner South Wind Corp., and Stewart Warner South Wind Division brands.
The proposed AD, published Aug. 20 in a notice of proposed rulemaking, would affect an estimated 6,000 aircraft, primarily Cessna and Piper models. The proposed AD modifies AD 81-09-09 issued in 1981, with a calendar time requirement added to the previous time-in-service inspection mandate. The proposed AD mandates a pressure decay test, component inspections, and also prohibits repair of the combustion tube.
The FAA estimates that individual inspections will cost $425, with additional costs of up to $6,000 to overhaul a defective heater and related parts, or $255 to remove the heater. The inspections are estimated to cost $2.55 million across the fleet ($425 for each of 6,000 affected aircraft. Overhaul of every installed unit in the fleet would cost about $36 million.)
The FAA did not specify the date or offer additional details about the accident that prompted it to investigate heaters of various models sold under the Meggitt and Stewart Warner South Wind brands. The new AD gives owners two calendar months or 10 hours of flight time to comply with the new inspection requirements.
“Regardless of whether the heater played a part in the above-referenced accident, this condition of deteriorated ignition components and smoke and fumes in the cabin could lead to passenger injury on other airplanes incorporating such heaters if not inspected and corrected,” the FAA states in the Aug. 20 notice.
AOPA is reviewing the proposed AD, and will submit comments. Comments are due Oct. 6, and can be submitted online or by mail to the address listed in the notice.
AOPA Online Associate Editor Jim Moore joined AOPA in 2011 and is an instrument-rated private pilot who enjoys competition aerobatics.
Wind and Gusts,
Safety and Education,
The FAA has issued two airworthiness directives that will take effect on April 26 affecting some Ces...
AOPA and the FAA recently hosted a two-day GA Engine Summit to discuss ways for the industry and gov...
There were 2,484 Piper Tomahawk trainers built from 1977 to 1982.
VOLUNTEER AT AN AOPA FLY-IN NEAR YOU!
SHARE YOUR PASSION. VOLUNTEER AT AN AOPA FLY-IN. CLICK TO LEARN MORE >>>
VOLUNTEER LOCALLY AT AOPA FLY-IN! CLICK TO LEARN MORE >>>
BE A PART OF THE FLY-IN VOLUNTEER CREW! CLICK TO LEARN MORE >>>