May 15, 2014
By Elizabeth A Tennyson
AOPA is once again asking the FAA to withdraw a proposed airworthiness directive (AD) that could affect thousands of ECi cylinders. The association repeated its request in formal comments on the FAA’s Initial Regulatory Flexibility Analysis.
In the May 12 comments, AOPA noted that the FAA’s own analysis indicates the agency underestimated the impact of the proposed AD, which would have substantial effects on more than 600 small Part 135 operators and another 5,000 small air services businesses.
At issue is a proposal calling for repetitive inspection and early retirement of replacement cylinders with serial numbers manufactured between May 2003 and October 2009 by Airmotive Engineering Corp. and marketed by Engine Components International Division, better known as ECi.
“From the beginning we’ve argued that this AD is not justified by the evidence, and this analysis only reinforces that belief,” said Rob Hackman, AOPA vice president of regulatory affairs. “As written, the proposal is overly broad and the suggested remedy could cause serious economic and safety problems. There have been no known cases of an accident or injury being caused by failure of the affected cylinders, so we want the FAA to withdraw the proposal and re-evaluate the evidence.”
The FAA originally estimated the proposed AD would cost $82.6 million and affect 6,000 aircraft with Continental 520 and 550 engines. But AOPA believes costs would exceed $100 million as aircraft are grounded for extended periods of time. The possible safety ramifications of inadequate capacity at overhaul facilities and the sudden need to replace thousands of cylinders in the field could create additional safety issues.
“Any airworthiness directive should be based on solid evidence,” said Hackman. “Given the available data, there are more appropriate and less draconian ways to address these safety concerns.”
The National Transportation Safety Board had recommended recurring inspection of the cylinders, rather than early retirement and replacement, a solution which AOPA argues is more appropriate given the small number of cases involved. According to AOPA’s own analysis of the supporting data provided by the FAA, the AD proposal is based on only 15 cases of documented cylinder failures out of a population of some 30,000 cylinders.
Director of Government Affairs and Executive Communications Elizabeth Tennyson joined AOPA in 1998, the same year she earned her private pilot certificate. She also holds an instrument rating and enjoys jumping out of planes almost as much as flying them.
General Aviation Statistics,
The FAA on Feb. 23 issued a special airworthiness information bulletin recommending preflight inspection of Robinson R44 and R44 II main rotors.
The FAA’s supplemental notice of proposed rulemaking on ECi cylinders is not justified and doesn’t account for economic and safety issues, AOPA said in formal comments.
An FAA emergency airworthiness directive calls for inspections of certain Enstrom helicopter models after a main rotor separation killed two.
VOLUNTEER AT AN AOPA FLY-IN NEAR YOU!
SHARE YOUR PASSION. VOLUNTEER AT AN AOPA FLY-IN. CLICK TO LEARN MORE >>>
VOLUNTEER LOCALLY AT AOPA FLY-IN! CLICK TO LEARN MORE >>>
BE A PART OF THE FLY-IN VOLUNTEER CREW! CLICK TO LEARN MORE >>>