High Altitude Flying

altimeter

Importance to Members

Most pilots don't think too much about using portable oxygen. Sure, everyone knows that you have to use supplemental oxygen if you fly more than 30 minutes at cabin pressure altitudes of 12,500 feet or higher. And that at cabin altitudes above 14,000 feet pilots must use oxygen at all times. And that above 15,000 feet each occupant of the aircraft must be provided supplemental oxygen. All of this is spelled out in Federal Aviation Regulations Part 91.211.

So are the rules for oxygen use in pressurized airplanes, which are governed by the times necessary to descend to safe altitudes in the event of a cabin depressurization. (Above FL250, a 10-minute supply; between FL350 and FL410, one pilot must wear a mask if cabin pressures rise above 14,000 feet msl — unless there are two pilots at the controls and they have quick-donning masks available.

From textbooks and stories of — or direct experience with — sessions in FAA-approved altitude chambers, pilots also know something about the dangers of hypoxia (insufficient oxygen) at altitude. Specifically, as the blood's oxygen saturation drops with altitude, a series of symptoms — all of them dangerous — can set in.

Overview

The air we breathe at the surface is roughly 79 percent nitrogen and other gases, and 21 percent oxygen. Lots of bad things happen when the blood's oxygen saturation drops. Night vision goes first, as retinal function begins to deteriorate at altitudes as low as 5,000 feet. Nausea, apprehension, tunnel vision, headaches, fatigue, dizziness, blurred vision, tingling sensations, numbness, and mental confusion are some of the other symptoms, and they can vary from individual to individual.

Technical Information

The common symptoms of hypoxia include increased breathing rate, dizziness, headache, sweating, reduced peripheral vision, and fatigue, but the most insidious symptom is a feeling of euphoria. Pilots suffering from hypoxia often experience a false sense of security rather than a sense of the danger inherent to this condition.

Hypoxia also impairs night vision. Because the rod cells in the eye, which give us night vision, require a lot of oxygen, a lack of oxygen causes visual impairment.

For pilots, hypoxia's adverse effects are described in terms of time of useful consciousness (TUC) and effective performance time (EPT).

TUC is a measure of your ability to function in a meaningful way. In other words, it's a kind of threshold on the pathway to becoming, first, something like a drooling fool, and second, unconscious and certifiably out of it.

EPT is defined as the time from the loss of significant oxygen to the time when you are no longer able to perform tasks in a safe and efficient manner. This is a dangerous condition, because hypoxia's onset is subtle. Pilots may think they're doing just fine — and in fact, may well have things under control — even though their EPT is dwindling away, and the countdown clock to unconsciousness is surely running. This false sense of well-being is, in itself, a symptom of hypoxia. But usually, at this point the pilot doesn't care.

People are not the same. Even though we've just been talking in terms of EPT and TUC guidelines, it's time for a reminder: Not all pilots have the same EPT or TUC. If you're a smoker, under a great deal of stress, or don’t exercise regularly to increase your heart rate, your EPT and TUC will be considerably shorter than the published guidelines. A pack-a-day cigarette smoker is physiologically hypoxic at sea level. The smoker's lungs are so damaged that they're incapable of absorbing as much oxygen as those of a nonsmoker, so at sea level, the smoker's blood-oxygen concentrations are already at the 7,000-foot level.

For this reason, smokers and those with more sedentary lifestyles lose consciousness faster at altitude than the smoke-free and fit, and they should use begin using oxygen at altitudes lower than required by the regulations. Other day-to-day factors such as nutrition, alcohol use, and quality and amount of sleep can also affect your oxygen requirements. There's even evidence that poor air quality can lower your blood oxygen saturation level. Maybe that's why "oxygen bars" are seen in high pollution metropolitan areas like Los Angeles, Mexico City, Tokyo.

Doctors and hospital staff want to see your blood oxygen saturation level at 96 to 98 percent. That's considered normal. You can measure O2 saturation with a relatively inexpensive pulse oximeter that clips over your finger tip. A 100-percent level is as good as it gets, and 95 percent is considered a minimum. An oxygen saturation level below 90 percent is a warning sign. That's when patients — and pilots — begin to experience hypoxia.

Additional Resources

Oxygen Use in Aviation
Discusses the FARs, physiology and hypoxia, and various oxygen systems.

Safety Pilot, Landmark Accidents
Into thin air - a pilot unknowingly takes his last breath
Air Safety Institute Accident Analysis

Hypoxia, poor planning a deadly combination
Air Safety Institute Accident Analysis

Embry-Riddle hypoxia training open to pilots
Embry Riddle Aeronautical University in Daytona Beach, Fla., has its own normobaric “altitude chamber” that’s open to the public.

ASI Safety Spotlight: Hypoxia Impairment Dooms Flight
An Air Safety Institute accident analysis.

ASI Safety Quiz on Hypoxia
See how much you really know about hypoxia in this safety quiz from the Air Safety Institute.

Fly Well: Diving to Great Heights
The hypoxic brain may quite blissfully ignore the strident call of a hypoxia alarm. So the secret is simple: prevention.

From the AOPA Archives

Continuing Ed: High Flying
Why Take the Low Road?
AOPA Flight Training, January 2004
Of all the decisions to be made when planning a flight, picking a cruise altitude may get the shortest shrift, the least attention.

Never Again Online
Off Radar in the Mojave Triangle
AOPA Pilot, October 2003

Friends in High Places
Learn To Fly the Mountains with Someone Who Knows
AOPA Flight Training, July 2003

October 23, 1999, was a beautiful day in the mountains near Aspen, Colorado. At approximately 12:28 p.m. Mountain Standard Time, N9548A took off and headed up the valley to the east, through Independence Pass, across the Rampart Range of the Rocky Mountains and into Colorado Springs. The Cessna 172R did not arrive at its destination.

Instructor Report: Simulated Mountains
Even Flatlanders Should Know How to Fly the Hills
AOPA Flight Training, February 2003

Years ago, I worked as the full-time "aviation safety guy" for the state of New Mexico, working to encourage safe flying in the aptly named Land of Enchantment. It was a great job, but there was one discouraging part: seeing the number of "flatlander" pilots who would arrive without realizing how different flight operations can be when field elevations are 5,000 or 6,000 feet or more, and — in the summer, at least — density altitudes can be close to 10,000 feet.

Staying Alive
Pressurization and environmental systems are vital
AOPA Pilot, October 2002

Turbine airplanes — and some piston aircraft — fly at altitudes that are incompatible with human life, and yet the pilots and passengers are healthy and happy because of pressurization and environmental systems on board.

Airframe and Powerplant: Hypoxia Lowdown
Now I use GUMPB
AOPA Pilot, March 2002

We all learned a little about hypoxia during flight training, but only a few of us have actually determined how, or at what altitude, hypoxia begins to affect our flying.

In the Lee of Giants
Riding high on mountain waves
AOPA Pilot, December 2001

Most of the time the rotor here is benign, but it has been known to generate forces of plus or minus 15 Gs.

Preflight Yourself, Then Your Airplane
Watch out for the invisible dangers
AOPA Pilot, November 2001

Let's talk about the less overt hazards to your safety.

Pilot Counsel
Supplemental oxygen
AOPA Pilot, June 2001

As general aviation pilots, we are charged with knowing the regulatory requirements for supplemental oxygen aboard the aircraft that we fly.

Going Up: The Elevator to the 2,500th Floor
AOPA Flight Training, May 2001

There is an elevator of sorts inside Building 1045, an unassuming one-story red brick structure on the west side of Andrews Air Force Base outside Washington, D.C. It is the home of the Eighty-ninth Physiological Training Flight, where more than 2,500 military and civilian personnel attend altitude chamber training each year. Here private pilots, flight surgeons, nurses, flight engineers, navigators, air traffic controllers, and reservists get to see how their bodies react to oxygen deprivation.

Training Topics: Legal Briefing
A Breath of Fresh Air
AOPA Flight Training, March 2001

You're taught early in your aviation training about potential medical risks associated with flying, including hypoxia, a condition caused by an inadequate oxygen supply to the body.

Above It All: Flying High in the Mountains
AOPA Flight Training, July 2000

But if you've never flown in mountainous terrain, how do you know just what constitutes high altitude?

Pilot Products
Breath of Life emergency oxygen system
AOPA Pilot, January 2000
The crash of a Learjet 35 carrying golfer Payne Stewart brought renewed interest in high-altitude flight physiology. How is it that all of those on board the airplane failed to realize that they were becoming hypoxic?

Flying Safe: Checkride
The Fragility Factor
AOPA Flight Training, November 1999

During your checkride, your examiner will ask you about aeromedical considerations in flying.

O 2 Issues
The whys and hows of oxygen use
AOPA Pilot, September 1998

Most pilots don't think too much about using portable oxygen.

Training Topics: Form and Function
Oxygen Systems
AOPA Flight Training, March 1998

In recent years there's been an increased focus on the subject of aeronautical decision making (ADM). Any time we allow ourselves to become hypoxic, we teeter on the brink of bad judgment.

FT Pro: Professional Development
Higher Learning: Advanced Training For Turbine Airplane Pilots
AOPA Flight Training, April 1997

A pilot flying a high-performance turbine aircraft faces high-altitude physiological, meteorological, and aerodynamic challenges far beyond anything he (or she) can expect when flying light aircraft at comparatively low altitudes. Such demands are much more likely to tax his judgment than his piloting skills.

Flying Smart: Detecting Hypoxia
AOPA Flight Training, March 1996

Albert Tissandier was a member of a three-man balloon crew attempting an altitude record in 1875, and the lone survivor of the first known fatal hypoxia incident.

By the Book: Hypoxia
AOPA Pilot, November 1991

The majority of our atmosphere — about four parts in five — is nitrogen. That's nice for microbes that can metabolize it, but it doesn't do much for humans, who need oxygen to survive.