June 2005 Volume 48 / Number 6
Safety Pilot: The Way to Fly
Skill and judgment keep you safe in the air and on the ground
In a recent survey, the majority of AOPA members surveyed agreed that in order to maintain the safety of the general aviation fleet, the FAA must make pilot education its highest priority rather than increasing regulation.
How safe is flight in today's general aviation America and where is it headed? Preliminary numbers for 2004 indicate, according to the NTSB, that it will be one of the safest years on record — but looking at a single year is not descriptive of the safety picture. Even a few years don't necessarily tell the full story.
For this special report the AOPA Air Safety Foundation looked back 10 years to generate some perspective. There are some things to be pleased about and a few areas that still need work. The numbers are derived from a subset of NTSB reports in the ASF accident database and include only fixed-wing aircraft weighing less than 12,500 pounds or, in other words, the kind of aircraft most GA pilots fly. (To see the graphs and trend lines from which this synopsis is derived, visit the AOPA ASF's Online Safety Center, click on the accident database, and look for GA Accidents — 10-Year Trend.)
The total accident rate per 100,000 flight hours decreased by 25.9 percent since 1994 (9.06 vs. 6.71) while the fatal accident rate per 100,000 hours also decreased nearly as much — 25.3 percent during the same period (1.82 vs. 1.36). The hours flown is a best guess derived from an annual survey taken by the FAA. However, there has been a slight accident rate increase over the past several years that is measured in hundredths of an accident. This implies a level of accuracy that just doesn't exist with today's tools. The general observation is that accident trends move very slowly — gaining a little here, losing a little there. That's why a long look is really the only way to get an accurate picture and then you can decide how to invest your safety resources.
Phase of flight is one way to categorize where accidents occur and then drill down to actual causal factors. There was a slight uptick in takeoff and climb accidents in both fatal and nonfatal categories. In total accidents this accounts for about 20 percent of all accidents and a little less than that for fatals. It's logical that this would be a problem area because there is frequently little altitude or time to solve a problem or to maneuver. Regardless of whether it is a mechanical failure or pilot induced, time, airspeed, and altitude are all in short supply. In any event, it's essential to have a contingency plan in the event of a power loss at a critical time.
With engine failures, basic statistics tell the story. There are far more single-engine accidents because a lot more singles are flying and, if the engine stops, an accident or at least an off-airport landing is a high probability. In multiengine aircraft there are very few accidents, and we have no record of how many engine failures there are when the aircraft landed safely. However, in those incidents where a twin does have an accident it is much more likely to be fatal. The "lethality index," or percentage of accidents that result in death, in singles is about one in 10 while in twins it runs in the 50-percent range, or one out of two. The bigger they are, the harder they fall, and that's why so much multiengine training is devoted to single-engine operations.
It's amazing that fuel mismanagement still occupies a significant line item in the statistics. In 1994, just more than 14 percent of the accidents involved attempting to run an engine on pure air, and by 2003 the number had only dropped to 12.8 percent. New production aircraft are doing better in this category and the gold star goes to Cessna, whose new production singles, more than 5,000 built since 1995 when it completely redesigned the low-fuel-warning system, have not had a single fuel-mismanagement accident.
Accidents involving poor-weather decision making remain essentially flat, accounting for about 4 percent of the total and 14 percent of the fatal mishaps. Much has been written about this, and while weather information has been gradually getting better, weather is still a major impediment to reliable cross-country flight. The FAA, National Weather Service, AOPA Air Safety Foundation, and NTSB have and will continue to put emphasis on improving forecasts, education, and pilot decision making. For GA pilots, there is much to learn since most of our aircraft or for many, our pilot skills, are just not very weather tolerant.
Bad approaches, both VFR and in instrument meteorological conditions (IMC) continue. While VFR accident numbers and percentages have always been the higher of the two, there are so relatively few IFR approaches as a denominator that this has to rank as a high-risk category. Failure to follow procedure and difficulty in believing that minimums really mean just that are frequent probable causes. The regression lines since 1994 show a marginal improvement in IFR, but this is an area where ASF will put additional resources.
Identical comments apply to day and night approaches, although in 2003 there was a real percentage spike in daylight accidents. Night flying is much more dangerous on a per-approach basis. There is no explanation for the spike and it confirms our belief that looking at a single year is almost guaranteed to mislead.
Accidents that occur during go-around remain stubbornly at roughly 4 percent for both total and fatal mishaps. Our observation is that some pilots lack basic physical aircraft handling skills and that this maneuver is seldom practiced.
Low-level maneuvering flight is a catch-all category for stall-spin accidents, the low pass, an attempt to return to the runway after an engine failure, poorly executed aerobatics, and the like. It accounts for nearly 30 percent of the fatal accidents and around 10 percent of the total accidents. It is the leading phase of flight for fatal mishaps. ASF has produced several seminars and a DVD program on the topic to educate pilots on the hazards and the common-sense approaches to avoid becoming a victim. This category is gradually declining, with fatal maneuvering accidents down from 28 percent in 1994 to 25 percent in 2003. This is an area that clearly needs more emphasis.
Every flight ends in a landing and some just aren't very successful. Unfortunately, the total trend is up and landing accidents continue to account for more than 30 percent of the total, but only about 3 percent of the fatals. (See "Safety Pilot: Not-So-Happy Landings," March Pilot.) More accidents occur during landing than any other phase of flight. It's been said that perfect landings are easy; it's just that nobody knows the secret. Low-time pilots and those new to a particular model of aircraft are the most vulnerable.
In a recent survey, 55 percent of AOPA members surveyed agreed that aviation manufacturers should be responsible for the cost of airworthiness directives and service bulletins.
There are no surprises when pitting man against machine. Machine wins every time and, in rough terms, pilot-causal factors compared to equipment failure average 3- or 4-to-1. Stated another way, between 70 and 80 percent of all accidents are attributed to the pilot. The hardware is reliable, if you maintain it properly. The reason is simple — when a particular part of an aircraft consistently malfunctions, it gets fixed or replaced through service bulletins or airworthiness directives. Unfortunately, we can't re-engineer pilots nearly as efficiently. Human problem areas are consistent and persistent with slow improvement.
GA safety continues an evolutionary improvement. Technology and training are gradually improving the record. Arrival of new technologically advanced aircraft and some of the retrofit equipment may make a difference, although it's too soon to tell. Pilot proficiency remains essential, so in the meantime, fly as if your life depends upon skill and judgment — it does.
Bruce Landsberg, executive director of AOPA Air Safety Foundation, has more than three decades of experience in the cockpit and in promoting safety. He has researched and written hundreds of magazine articles and safety reports and analyzed hundreds of accidents for various industry groups. He's been involved in new pilot, air carrier, and corporate pilot training and safety.